Experimental Study of the Model Compartment of the Low-Pressure Cylinder of K-320-240 Turbines of JSC “Turboatom”

image_print
DOI https://doi.org/10.15407/pmach2019.04.006
Journal Journal of Mechanical Engineering – Problemy Mashynobuduvannia
Publisher A. Podgorny Institute for Mechanical Engineering Problems
National Academy of Science of Ukraine
ISSN 0131-2928 (Print), 2411-0779 (Online)
Issue Vol. 22, no. 4, 2019 (December)
Pages 6-11
Cited by J. of Mech. Eng., 2019, vol. 22, no. 4, pp. 6-11

 

Authors

Svitlana V. Alyokhina, A. Podgorny Institute of Mechanical Engineering Problems of NASU (2/10, Pozharskyi St., Kharkiv, 61046, Ukraine), V. N. Karazin Kharkiv National University (4, Svobody Sq., Kharkiv, 61022, Ukraine), e-mail: alyokhina@ipmach.kharkov.ua, ORCID: 0000-0002-2967-0150

Mykhailo H. Ishchenko, Joint-Stock Company Turboatom (199, Moskovskyi Ave., Kharkiv, 61037, Ukraine), ORCID: 0000-0003-2251-5104

Liubov O. Slaston, Joint-Stock Company Turboatom (199, Moskovskyi Ave., Kharkiv, 61037, Ukraine), ORCID: 0000-0002-9268-8134

Riza B. Sherfedinov, Joint-Stock Company  Turboatom (199, Moskovskyi Ave., Kharkiv, 61037, Ukraine), ORCID: 0000-0002-5947-7802

 

Abstract

A reduction in the efficiency of the last stages of powerful steam turbines, as well as their reliability due to an increase in the disturbing forces acting on the blades, is an urgent study subject, which requires a comprehensive analysis of gas-dynamic processes in these parts of the turbines. To determine the integral and gas-dynamic characteristics of the last LP stages of K-320-240 turbines under variable operating conditions, and develop recommendations for their further improvement, experimental studies of the model flow path of the cylinder compartment were conducted using the gas-dynamic test stand 0102 of Turboatom JSC. As a result, it was established that closing the moisture removal slot increases the efficiency of the last LP stage by 2–7% in the range of volumetric steam flow rate changes from 900 to 2900 m3/s. With a nominal operating mode, the efficiency of the two penultimate LP stages is 0.786. With a significant change in the volumetric steam flow rate downstream of the last stage in the previously specified limits, the compartment efficiency changes by less than 0.9%. As a result of the experimental studies, there was determined the possibility of increasing the efficiency of the flow path of the K-320-23, 5-4 turbine LPC. The results of the above studies were used to modernize the K-320-240 turbines, which made it possible to increase the efficiency of the compartments of the last three LPC stages by 1.3%, of which 0.9% were due to the modernization of the third stage and 0.4%, due to the sealing of the fourth stage radial clearance, and use the results of the study to improve the LPC of the K-325-23.5 turbine.

 

Keywords: volumetric steam flow rate, low pressure cylinder, steam turbine, efficiency.

 

Full text: Download in PDF

 

References

  1. Shvetsov, V. L, Zarubin, L. A., Boguslavskaya, Z. D., & Shvedova, T. I. (2009). Rezultaty eksperimentalnykh issledovaniy modelnogo otseka tsilindra nizkogo davleniya turbiny K-320-240 OAO “Turboatom” [Results of experimental studies of the model compartment of the low-pressure cylinder of the K-320-240 turbine of OJSC Turboatom]. Problemy mashinostroyeniya – Journal of Mechanical Engineering, vol. 12, no. 1, pp. 16–25 (in Russian).
  2. Ponomarev, V. N. (1977). Povysheniye ekonomichnosti poslednikh stupeney s rezkim raskrytiyem protochnoy chasti [Improving the efficiency of the last stages with a sharp opening of the flow path]: dis. … Dr. Sci. (Engineering). Kharkov Polytechnic Institute named after V. I. Lenin, 435 p. (in Russian).
  3. Matveenko, V. A. & Agafonov, B. N. (1984). Osobennosti raboty TSND parovykh turbin na maloraskhodnykh rezhimakh: obzornaya informatsiya [Features of the operation of the low-pressure cylinder of steam turbines at low flow rates: Overview information]. Issue 12. Moscow: NIIEInformenergomash, 54 p. (in Russian).
  4. Shnee, Ya. I., Garkusha, A. V., & Shvedova, T. I. (1976). Copyright certificate 527521 SSSR, MKIF01 D1/04. Poslednyaya stupen’ osevoy kondensatsionnoy turbiny [The last stage of the axial condensation turbine]. Claimed 17.06.75; published 05.09.76, newsletter no. 33, 3 p. (in Russian).

 

Received 28 November 2019

Published 30 December 2019